| Jinma Tips |
| 32 hour break-in service Change engine oil/filter (Delo 400 15W-40) Change fuel filter Change Injector Pump oil (Delo 400) Change Transmission Oil (85W-90 gear oil) Change Front Axle oil (85W-90) Change Hydraulic tank oil (Hydraulic Fluid) 2006 and newer Replace Hydraulic suction filter (NAPA 1551) |
| Every 100 hours or once a year which every come first Change engine oil/fiter Replace Air Filter if needed Check Belts and Hoses |
| Every 200 hours or once every two years Change fuel filter Change Hydraulic Tank Oil |
| Monthy Grease Look for loose bolts and tighten Check tire pressures: front 29# rear 17# |
| We recommend storing tractor out of the weather to keep condensation from forming in the transmission and add life to the paint and rubber on tractor. |
| Use the glow plug in cold temperatures to allow the engine to start quicker. 15-25 seconds of glow plug is all that is needed. Any more than glow plugs can be damaged. |
| When moving dirt, use L1 or R1 to extend the clutch life. |
| With Mowers, set 3pt raise limit so mower deck does not touch driveline when mower is raised. Shorten the toplink will allow mower to be raised higher without touching driveline. |
| Oil Filter 2001 and older Factory Number: JX0706P NAPA:1381 2002 and newer Factory Number: CX0706 Use Factory filter from dealer or NAPA: 3195 (Need to extend nipple threads) Laidong LL385 in 4/06 and newer tractors from Adams Tractors NAPA 1516 Fuel Filter Factory Number: CX0706 NAPA: 3195 Wix: 33195 Air Filter NAPA: 2276 Hydraulic Filter 2006 and newer NAPA 1551 |
| Upper Radiator Hose Gates: 25473 Lower Radiator Hose Gates: 25480 Bypass Hose Gates 20338 Thermostat Gates 33508 180deg Gates 33509 195deg Radiator Cap Stant 10228 Exhaust Gasket NAPA F5645 |
| JM-284 Y385 cross references |
| Keyswitch retrofit Ford Keyswitch E7NN11N501AB (Wire Terminal change is required) Alternate #C7NN11501AB Fan Belt Gates A-37 or A-38 Rubber Fuel Lines Gates rubber hose Alternator retrofit Delco Remy 10 SI alt (internal regulator off 1988 Chevy Pickup) Voltage Regulator NAPA: ECHVR32 VR706 (68 Chrysler) Battery Group 31 HP-31D or Interstate 31-ECL |
| Every 300 hours or once every three years Change Transmission Oil Change Hydraulic Oil and Clean suction screen Change Front Axle Oil Change Injector pump Oil |
| ***To avoid gear damage, pull heavy loads in forward gears not reverse gears. Front axle gears are not designed as strong as rear axle gears.*** |
| When using a loader, keep a heavy implement/weight on rear of tractor, this will help keep tractor from tipping, travel with buck low as possible and avoid side hills, keep weight in bucket centered. |
| Jinma Safety/Operating Tips |